ComplaintsforCarolina Carports, Inc.

• Initial Complaint

  11/05/2024

  Complaint Type:

  Order Issues

  Status:

  Answered

  More info

  Building installed April 2024, rust noticed inside building support. ****** notified initially in June, sent pictures of area of concern that was under warranty. No contact until 8 weeks later. Unable to assign a crew to replace the rusted supports. Still attempting to schedule replacement almost 6 months later for work that is under warranty. Buyer beware, they will gladly make the sell, but no follow up for issues and repairs that are covered under their stated warranty!

  Business response

  11/05/2024

  I am in receipt of the customers concerns. 

  To clarify, the area of concern reported is not part of the structural framing and is not part of the rust through warranty. The area is a welded area where galvanized spray is used. Those areas do have to be maintained over time, especially in an area at the coast where there is salt water which can cause corrosion. Regular maintenance is essential. We did issue a service order as a courtesy to go out and respray the area.

  We received the report on 7/5/24. We attempted to schedule twice in August and once in October with no returned phone call. The customer accepted scheduling for November 7th. The contractor is ahead of schedule due to a foundation not being completed properly by another customer. We contacted Mrs. ****** to let her know the crew could come today, she refused. 

  We have advised that we will place her on the next truck in the area. 

   

  Sincerely,

  ******* *****

  CCI General Manager

  ***********************

• Initial Complaint

  09/23/2024

  Complaint Type:

  Service or Repair Issues

  Status:

  Answered

  More info

  They tried to install the barn I purchased, but their truck weighed too much and they tore up the yard. The tow truck driver that got them out said, they were carrying more weight than is even legal to carry on the roads per DPS.

  Business response

  09/24/2024

  I am in receipt of the customers concerns. 

  The contractors are independent, they are not employed by CCI so this should not be filed against CCI. We are not on site, we do not transport or install. The contractors purchase materials from CCI, kind of like any construction company goes to *****. We are the manufacturer only. They load their own trailers. While we appreciate the tow company's opinions, they have no way of evaluating weight without weighing the trailer. Typically, the contractors load in **, there is a weigh station about 1 mile from there, they weigh before leaving out. For CCI, we have no part in any of that process. 

  In terms of the yard, the customer can submit photos and two estimates for yard repair. We would then get with the contractor regarding a potential insurance claim, assuming the customer's concerns and estimates are validated. 

   

  Sincerely,

  ******* *****

  CCI General Manager 

  ***********************

  Customer response

  09/24/2024

   I am rejecting this response because:

  Carolina Carports is who was hired in contract to provide the service. 

  I purchased from ************** Outlet, in the contract it states, that Carolina Carports *** is who will be RESPONSIBLE for the installation. It says nothing about subcontractors, or their use of subcontractors. If there is a need for them to engage the subcontractor they hired to reimburse them, that is their responsibility. They should take responsibility of the damages done by the subcontractor, as I never agreed to do business with a subcontractor only CCI. 

  Additionally, I did submit the complaint AND pictures the exact day the damages were incurred. (9/9/24)

  I called them, followed the directions of what they asked (estimates for repair from 2-3 contractors) and provided 1 in a timely manner, and gave them the info to pay for the $50 estimate for the 2nd, after 1 week, the contractor contacted me who was waiting for payment for his estimate, and told me they never reached out to him. He subsequently provided me the estimate, and I relayed to CCI, with a 3rd estimate. 

  CCI has dragged their feet and been unresponsive (gaslighting/ghosting) me through the whole process. 

   

  
  

  Business response

  09/25/2024

  All information regarding CCI states that we use qualified independent contractors, that information is public knowledge. 

  In terms of the damages, CCI has no recourse for filing a claim directly through CCI as we have no presence on site. If we filed the claim through CCI, it would be denied. Additionally, CCI cannot file a claim against the contractor for reimbursement with the insurance as we are not the damaged party. 

  The contractors clearly work out of town. The information was provided to the contractor upon his return. The insurance claim has been filed. Once an adjuster is assigned, the insurance company will reach out directly to the customer and contractor for statements and/or additional information that may be needed. 

  Once a claim number has been assigned, we are happy to help by passing that information along. 

  Sincerely,

  ******* *****

  CCI General Manager

  Customer response

  09/26/2024

   I am rejecting this response because: 

  In response to your public knowledge of the use of contractors, I do see that now on your website. However, again it is not stated on the paperwork/contract with ******* Since the purchase was made from ******, and it states CCI will be performing the installation, it might benefit your future customers to have it in the initial communications from ****** that CCI does not actually perform the installations, rather that CCI is responsible to subcontract the installation to other contractors. 

  Otherwise, yes a claim was finally filed by your contractor and the agent has reached out to me to begin the process.

   

  
  

• Initial Complaint

  09/11/2024

  Complaint Type:

  Product Issues

  Status:

  Answered

  More info

  For several months my husband *********************** *************) and I dealt with ****'s Factory Outlet hiring them to build a shed and a pavilion on our property at **********************************************************************************. In August ************************************************** September we ordered the pavilion and paid them a deposit. They said that we needed blueprints from their 3rd party called Carolina Carports so we paid them $175 on September 6th and $175 on September 27th. (A total of $350). They said that the ground under the shed had to be level so we spent several weeks digging out the grass to make it level. They said it needed to have a gravel base so ***** took days off work and rented a trailer from Sunbelt Rentals for $123.61 on November 17, 2023 and bought several tons of gravel from Earthworks for $149.80 to prepare for the shed. We were in constant contact with the company sending pictures of our updates in emails and talking to them on the phone. They said we needed permits so we made several trips to the Bay County Building Department to obtain those. On October 23, 2023 we paid $373.83 for the building permit for the shed. On December 5, 2023 we paid $322.48 for the permit for the pavilion.We waited for several more weeks and were finally told that they would arrive to build the shed on January 22, 2024. A truck arrived in the morning and after about 5 minutes the builder said the site for the shed and pavilion were too far from the driveway and they couldn't build them. We have wasted so much time and money dealing with the incompetence and fraudulent business practices of this company. ****'s Factory Outlet refunded us the deposits for the shed and pavilion on January 22, 2024 but Carolina Carports hasn't refunded us for the $350 we paid for the blueprints. They should also refund us for $273.41 we spent laying gravel, and the $696.31 we paid for the permits. The total of these expenses is: $1,319.72.

  Business response

  09/12/2024

  I am in receipt of the customer's concerns. 

  Everything the customer has described regarding the engineered plans, the permit process and the leveling are all within standard procedure. Florida is very strict regarding their permit process. Plans do have to be funded prior to development as they are provided by an engineer licensed in the state of *******. All plans for the purpose of permitting are non-refundable. The permit fees are the responsibility of the customer as is providing a level foundation. The foundation must be level within 3-4'' for a successful install. 

  Upon arrival the crew immediately walked from the area they could parked and measured a 250 ft. distance between the unloading area and the job site. Per the contract terms, if the contractor has to carry the materials, there are labor fees assessed for that. CCI does not receive or retain any portion of that charge, it is paid to the crew for the additional time in transporting the materials and the fact that this takes away from them being able to move on to the next jobsite, essentially putting their entire work week behind. When the crew got to the install site, they immediately measured prior to unloading. The foundations where more than 8'' off level. The crew sent photos to the state rep here at CCI. 

  The crew called while on site, he was speaking with ***** and had CCI on speaker phone. He explained that the area would have to be leveled within 3-4'', there would need to be closer access to the job site or there would be a labor fee and of course, any failed install due to foundation issues incurs a return/restocking fee. The customer stated on site that he was unsure whether he wanted to invest more money into the project. we later received a cancellation from the dealer, ****'s Factory Outlet. 

  There are no compensable damages in this situation. The customer was required to get plans to get a permit, they are required to pay their permit fees. The only issue here is access to the site and the site not being level, those are both customer responsibilities. If the customer wants to level their land, allow access to the site and reinstate their orders and reinstate their permits, they can have their buildings installed. The fact is that CCI manufactured the parts for these units, dispatched a contractor who did not get to work, the crew traveled out of state and incurred expenses in travel which CCI had to reimburse. This has resulted in a significant loss on CCI's end due to the fact that the customer did not adhere to the contract terms. 

   

  Sincerely,

  *************************

  CCI General Manager

  ***********************

  Customer response

  09/12/2024

   We are rejecting this response because: we still have not been refunded the $350 for the blueprints. We called your company almost daily to get information on where in the yard to prepare the sites for the shed and pavilion. We also struggled to figure out how you wanted us to level the site and what materials to use. We were never able to talk to anyone on the phone who knew anything about the building process. Months and months went by after we paid our deposits without any useful information or being able to contact anyone helpful.

  Either your communication process is just incompetently horrible or you are fraudulently misrepresenting your products and services. I'll assume it's the former if you refund me $350 for the blueprints and attempt to incorporate change in your company. Otherwise I will write to the **************************** of NC and the Department of Justice. My husband and I are intelligent and productive home-owners that tried out hardest to make this work. How many other people have lost huge amounts of money and time to your company? This needs to end. 
  
  

  
  

• Initial Complaint

  08/23/2024

  Complaint Type:

  Service or Repair Issues

  Status:

  Unresolved

  More info

  This complaint is pertains to a metal carport which was purchase original in 2014 which carries a 20 year corrosion warranty for the materials. Starting in/around 2021 the bottom rail of the carport started to rust. I sent photos to *********************** of Carolina Carports along with a detailed description of the ongoing state of the materials. Several weeks past, and the only updated I could get is that my claim has been passed off to a scheduler. Weeks turned into months with no response. I reached out to re-open this claim back on July 18, 2024 and was informed that *********************** was no longer with the company, and was now dealing with *************************. I re-sent the old photos and a group on new photos document the rust which has now progressed to the point that the carport is structurally compromised. ****** informed me (by email) the he had passed my information for ***** who is a project manager there at the main office. Approximately 3 weeks went by with no response, so a located Sabras email on the web and reached out directly to her for an update. See this replied in a series of email with deflecting questing and statements about their policies and warranty without giving me an real information. The last email went exchanges went as follows: ....................Hello Lane,I have reviewed your photos and your contract We have a 20 year limited rust through warranty. It does appear that the installation area holds water, that is based on the photos and the discoloration on 1 side of the concrete versus the other. We are happy to deliver the baserail at no cost to you for self installation. Not enough room to provide you with the full chain of events, but basically, i was able to get the to agree to that their product was defective however they only want to provide the parts, and not provide the service of fix the issue. Furthermore, as a consumer self-replacement of these parts is not physically possible.

  Business response

  08/27/2024

  I am in receipt of the customers concerns and have been aware of the situation since ***** became involved. At no point does Sabra give any indication that this is a defective product. The photos indicate an area that has been submerged in water. There are numerous discoloration points. 

  Steel and/or metal cannot be submerged in water without repercussion. The warranty covers materials that have not been compromised. Below are the warranty statements:

  LIMITED WARRANTY
  20 year Limited Rust Through Warranty On:
  12 Gauge Framing
  Vertical Roof Style Up to Any Length
  Regular Style Up to 31 Long
  Boxed Eave Style Up to 31 Long
  Limited Lifetime Warranty on All Certified Units for Wind and Snow Loads
  
  10 year Limited Rust Through Warranty On:
  14 Gauge Framing
  1 Year Workmanship Warranty From The Date Of Installation
  All warranties assume normal care and maintenance using mild soap and water. We do not recommend the use of any harsh chemicals. Warranties are limited and non-transferable.
  ENVIRONMENT
  This limited warranty does not apply in the following cases:
  

  Attack from chemical agents, fumes, liquids, or solids other than direct rain falling onto product under warranty
  Contact with soils, ashes, fertilizers or other moisture retaining substances
  Failure to remove debris and/or failure to provide free drainage of water including internal condensation from all surfaces of the product
  Deterioration of the sheet caused by contact with green or wet timber or treated pine
  Installations subject to unusually corrosive environments at any time in the future
  Storm and tempest or other acts of God
  MAINTENANCE
  The paint film surface must be washed annually by cleaning with mild detergent and clean neutral water. The paint film surface must not be cleaned with abrasives or chemical cleaners.
  *All warranties and certifications will be immediately void if the buyer/owner alters the unit in any manner.

   

  The customer does not have a warranty due to the location and environmental impact from the holding of water. We graciously offered the customer a new base for self install as a courtesy. Additionally, the customer has no maintenance records. If the unit was not in an area that holds water, the customer still would not have a warranty due to the failure to maintain records of proper cleaning. We are happy to drop the baserail as previously stated. 

  Sincerely,

  *************************

  CCI General Manager

  ***********************

  Customer response

  08/27/2024

  To Whom it May Concern:
  In response to the CCIs statement, my carport has not been submerged in water, but it does get wet every time it rains as does virtually every other carport in existence.  Furthermore, as previously stated my driveway is properly sloped and does not retain water. I invite you to test this statement at any time.  Also, Ms. ************************* stated that the customer does not have maintenance records. This is correct. Despite being property maintained I dont have maintenance records nor does CCIs warranty conditions state that maintenance records are a condition of the warranty terms. 
  CCI has rightly agreed to replace the baserail(s) at this point; however the problem not being addressed is the complexity in replacing the baserails.  Realistically, replacing the baserails would require almost completely disassembling the carport and reassembling, or some combination of specialized lifting equipment to elevate and replace the baserails.  Either way, self replacement of the baserails with or without assistance from a subcontractor would likely cost in the neighborhood of replacing it with a new one which is not an option. 
  In my opinion CCI agreeing to replace the materials should obligate them to replace the parts.  Any other course of action will likely cause the carport to be damaged or compromised from its original state rendering any additional structural warranty void. 
  

  Respectfully. 
  

  
  

  Business response

  08/27/2024

  We are agreeing to provide the baserail as a courtesy to the customer. The area is discolored and evident that water has been a contributing factor. As copied in my previous response, warranties assume normal care and maintenance. This must be documented in order to prove such. We install over ****** buildings per year. We can't offer a warranty on a product that has no proof of maintenance. From a contractual standpoint, we are not obligated to even drop a baserail. We were simply trying to assist to our capabilities. It was not intended that the offer would be taken out of context or manipulated. There are still some companies out there that try to be kind to people in tough situations. It is unfortunate that was misconstrued. We remain committed to the drop off if the customer desires.  

• Initial Complaint

  08/21/2024

  Complaint Type:

  Order Issues

  Status:

  Answered

  More info

  My husband and I bought a carport from a dealer in ************. We have a signed contract. Do we have the price sheet that was published and given directly to us. Unfortunately, we were called by the company and told that that was an old price sheet and that they were going to increase the price by more than 20%. I want them to honor the price that is published and that I have a signed contract for

  Business response

  08/21/2024

  I am in receipt of the customers concerns. Yes, the price sheets used by the independent dealer, *******'s Auto Sales is severely outdated. 

  The price sheets are dated 2015. CCI has had 3 price increases since that time. The dealer has been emailed links to the new brochures at each occasion. Per the contract terms, CCI reserves the right to correct pricing errors made by dealers. CCI cannot process this order at that price. The dealer has been notified as well. 

  We understand the customer's frustrations, however, the terms are very clear in the signed binding contract. 

   

  Sincerely,

  *************************

  CCI General Manager

  ***********************

• Initial Complaint

  08/19/2024

  Complaint Type:

  Delivery Issues

  Status:

  Answered

  More info

  On February 15, 2024 I ordered a 20' x 30' metal carport from Power Steel Buildings, **** (Garage Buildings) and put a deposit down of $624.00. The order was then given to Carolina Carports to build, deliver and install. To date, the carport has not been delivered or installed at the location listed above. I have made numerous attempts to resolve but to no avail. I recently spoke with ***** at Carolina Carports who said they are looking at an install date between the end of July to the first of August and that they would call 2 weeks prior to give us an actual date. I never heard back from them. I called again today, August 19, 2024 and was sent to her voice mail, which I left a message. It has been 6 months since I first placed the order and I am exhausted just trying get the carport installed.

  Business response

  08/20/2024

  I am in receipt of the customers concerns. This order has not been delayed as stated. I have prepared a timeline to offer a better understanding. 

  February 16th - CCI received the customer's order from the dealer. The customer is in an area which requires a permit and site specific plans. 

  February 19th - Left message for customer to obtain payment for site specific plans. 

  February 22nd - Customer called and stated that they did not want to pull a permit. Advised this area requires a permit, order placed on hold until permit is provided. 

  April 9th - Customer is working on permit. Hold until permit is issued. 

  July 8th - Customer called in ready, advised we need a copy of the permit or permit #.

  July 10th - Customer called with permit number. Order released from hold. 

   

  The customer has been waiting since July 10th when they took their order off hold. Lead times begin when the hold is released. The current lead times are 8-12 weeks. We are happy to process this order as soon as possible with the understanding that we do so in accordance to when each order was ready. If an opening becomes available prior, we are happy to provide a work in schedule. 

  Sincerely,

  *************************

  CCI General Manager

  ***********************

  Customer response

  08/22/2024

   I am rejecting this response because: The statements made by ******* with Carolina Carports are not accurate.

  Below are the facts:

  February 15, 2024 - Order was placed with Powerbilt Steel Buildings.

  April 8, 2024 - Received a call from ******** with Carolina Carports letting me know the carport was done and ready for install and wanted to set up an installation date.  I asked ******** if they had applied for the permit yet.  She said no and forwarded me to their permit department. Since no one answered, I had to leave a message.

  April 9, 2024 - I finally spoke with a gentleman in their permit department who said I was the one who needed to pull the permit.

  May 20, 2024 - Applied for permit and paid the $281.25 fee.

  May 31, 2024 - Received a call that the permit was ready.

  May 31, 2024 - Called ********. She did not answer so I left a message stating that we received the permit and asked that she call with an installation date.  I never heard back from her.

  June 13, 2024 - Sent an email to ************************* with Powerbilt Steel Buildings requesting his help to get this resolved. (See attached email).

  July 5, 2024 - Since I never heard back from Carolina Carports or ************************* (Powerbilt), I sent a demand letter to the two of them stating if I did not hear back from them by July 15, 2024 I was going to report them to BBB and to the ************************.  (See attached email).

  July 5, 2024 - ***** called and asked me to send him the permit information and he would call Carolina Carports to get this resolved. (See attached email to *****).

  July 15, 2024 - Since I did not hear back from Carolina Carports by the July 15th due date, I called that afternoon and spoke with ***** who said that our carport would be installed at the end of July or beginning of August.  She also said she would contact me two weeks prior with an installation date.  She never once mentioned anything about an 8 - 12 week lead time.  I did not proceed with contacting BBB or the ************************ because I was given an approximate installation date.

  August 19, 2024 - When the beginning of August came and went, and I did not receive a call from Carolina Carports is when I filed the complaint with BBB.

  If we have to submit for a new permit due to too much time has passed since the first one was issued, I will be demanding Carolina Carports pay for application fee.

  Business response

  08/23/2024

  I have reviewed incoming and outbound calls. It would appear that the customer primarily communicated with Powerbilt. CCI does not have record of the incoming calls between the customer and ********. I am not fully familiar with the staff at Powerbilt but it could be possible they have someone with that name there. Additionally, we have no ******** that handles FL. 

  CCI has never received any letter or demand from the customer. We have no emails or other communications. 

  The information provided regarding the permit process is correct, the customer is responsible for pulling the permit unless it is a commercial property or CCI is specifically requested to pull a permit. The notes, back dated and time stamped as well as calls do not reflect the information provided by the customer. 

  The 8-12 weeks is a standard lead time from the date that CCI has all information regarding the order. This includes permits, site photos, half down payments, etc. as they apply to each order. Some orders do get processed sooner as time slots open depending on customer availability. An order is not active until all the information is on file. CCI activated this order immediately upon receipt of the permit. I am unsure who ***** is, we received the permit from ********* at Powerbilt. 

  The customer was advised that **** take the order off hold, be placed in a route and they would receive a call when the contractor would be in the area. This order is currently projected for August 29th/30th. Those dates could change if weather or delays impact the schedule. The customer would receive a call from customer service to confirm. 

  Customer response

  08/23/2024

   I am rejecting this response because: Again, Carolina Carport's statements are not true. 

  Since they do not have any records of my phone calls to them, I am attaching call logs from February 2024 through August 2024 which will show I have made a total of 25 phone calls to Carolina Carports and received a total of 6 phone calls from them. 

  The phone call I received from ******** with Carolina Carport (**************) to let me know the carport was complete and she wanted to schedule an installation date was not on April 8th but was actually on April 9th.  Also, I called ******** (**************) on June 10th, the date we picked up the permit and not on May 31, the date we received the phone call that the permit had been approved. 

  
  

• Initial Complaint

  08/01/2024

  Complaint Type:

  Order Issues

  Status:

  Answered

  More info

  I paid the entire invoice on my job. The job is not complete and the company is ignoring my multiple attempts to contact them. I had been dealing with ***** and she will not respond. They still have yet to install the remaining door locks on my job.

  Business response

  08/01/2024

  I am in receipt of the customers concerns. 

  Sabra, one of our customer service managers, received an email from ****************** on 7/25/24 at 11:24am. He original email stated that the building was installed the previous week and that the crew was missing some hardware for the garage doors. ***** replied to his email on the same day at 2:11pm. She asked how many locks were missing. She advised that the 2-10x10 doors have 2 locks standard and the 2-8x8's come with 1 lock standard. 

  To date, the customer has not sent the information needed in order to issue a service order. We have no photos, we do not know which doors are missing locks or how many are missing. I will have ***** reach back out to the customer. However, we do need his cooperation to ensure that we send the correct products. The customer has only requested an update on completion but has not sent the needed information. We cannot provide a date until we have the info needed to issue a service order. 

   

  Sincerely,

  *************************

  CCI General Manager

  ************************************

  ***********************

  Customer response

  08/01/2024

   I am rejecting this response because:
  
  I responded the same day with the information needed. This is an attempt divert emphasis away from the fact that they are not responding to my emails. I have the email chain showing my responses along with the 4 other emails that they are ignoring. I will be happy to provide if needed. To again reiterate I need 4 more door locks that go on the 2 10x10 doors.

  Customer response

  08/01/2024

  The information has been provided to Sabra 2 times now. Hopefully that is sufficient since all the door locks are identical for rollup doors regardless of the size. So let me say it again. I need 4 garage door locks. 2 each for the 2 10x10 doors. Total 4 = locks.

  Business response

  08/02/2024

  The email only stated 3. It did not specify the which doors, size, any further information. Now he states 4 for the 10x10's. This information was not provided previously. We can issue a service order. 

  Customer response

  08/02/2024

   I am rejecting this response because:
  
  I provided the information previously. They originally said I didn't respond at all now they claim I did but apparently they didn't understand. Funny that nobody reached out to clarify if that was truly the case. I don't mind a business saying we dropped the ball and we will get it fixed. Just don't lie about. It is what it is. The company did finally reach out yesterday after BBB got involved but we will see if it gets resolved.

• Initial Complaint

  07/31/2024

  Complaint Type:

  Service or Repair Issues

  Status:

  Resolved

  More info

  We purchased a CERTIFIED (170MPH wind) carport on 7/16/22 at the ********* in ******, **. The Woodshed (no longer in business) was an authorized dealer for Carolina Carports (who the contract is with).On May 9, 2024, a storm came through with high winds. Two neighboring carports sustained no catastrophic damage, however, the anchors on our carport came out of the ground causing a collapse of the carport and damage to our RV.I attempted to contact Carolina Carports by phone and email on 5/9/24. We documented the damage with photos. On 5/15/24, the ************************ deemed the storm as not a tornado, but rather high winds. At the same time, the owners of the campground where the carport was installed required us to remove the carport due to safety. I emailed and called 6 additional times between 5/9/24 and 5/24/24 asking Carolina Carports to discuss and possibly honor their warranty. On 5/24/24 in an email I indicated that failure to respond would result in contact with the Missouri Attorney General and possible legal action. I received ZERO responses from my calls and emails. The company has not reponded to repeated attempts to contact them, thus have violated their advertised warranty. We are asking for a prorated refund of $4900 based on our calculation (we took cost of carport, 20 year life cycle, minus approximately 2 years of depreciation.

  Business response

  08/01/2024

  I am in receipt of the customers concerns. 

  I have went back through the timeframe noted using the phone number and email address we have on file for the customer. There have been no received/incoming calls or emails from this customer this calendar year. 

  We are happy to review the situation. We would need photos of the unit damage. 

  I have pulled the weather in the area. The unit is rated per the *** at a 3 second gust threshold. The unit is not rated for sustained winds. This area did have significant sustained winds. This would likely be a situation that is not covered under warranty and would require the customer to file an insurance claim. However, I cannot state that for certain until I have additional information. 

  The customer can email me direct at the email listed below. 

   

  Sincerely,

  *************************

  CCI General Manager

  ************************************

   

   

  Customer response

  08/05/2024

  Better Business Bureau:
  
  I have reviewed the response made by the business in reference to complaint ID ********, and I accept it.  *********** has reached out and have offered a generous solution which includes the replacement of the damaged product. 

• Initial Complaint

  07/18/2024

  Complaint Type:

  Sales and Advertising Issues

  Status:

  Unresolved

  More info

  We had a beautiful 30x40 metal building with 10x40 leantos put on our property. We were excited to get the inside built out for entertainment purposes. We started noticing that the 3 windows that were not under the lean to leaked during rain storms. After inspection- all 11 windows WERE NOT sealed at all. In fact you could see directly through into the building in some gaps. We have tried 4 different sealant applications to nooks and crannies without success. When approached about this issue we were advised since we added spray foam insulation into the building our warranty was void. However, the complaint is by the original erecting of the building- not craftsmanship thereafter.This is highly discouraging as this manufacturer has a monopoly on this side of the state and there arent any others during the same work.

  Business response

  07/19/2024

  I am in receipt of the customers concerns. 

  ********************** buildings are designed by engineers for storage use purposes only. This information is listed on the blueprints for every unit. They are not designed for habitable space. 

  The terms, conditions and warranties very clearly state that ANY alterations to the structure immediately void all warranties. If ever a customer mentions spray foam, we advise that is the last application that needs to be used on this type of unit. Spray foam expands, it creates gaps and will cause a unit to leak significantly. 

  We certainly sympathize with the situation but there is absolutely nothing that CCI can do to assist. The customer has voided all warranty on the structure. The alterations are impactful to the structural integrity of the unit. Additionally the customer has breached the intended design/use of the structure. We are hopeful that the customer followed proper protocol and enlisted the assistance of an engineer, architect and licensed contractor to properly permit and record their upfitting with the county, otherwise, they may be forced to remove the unit if reported. 

  Sincerely,

  *************************

  CCI General Manager

  ***********************

  ************************************

  Customer response

  07/23/2024

   I am rejecting this response because:
  Spray foam has not created the fact that these windows were not properly sealed to keep rain from entering the building at the time of installation.  We are asking for proper sealing of the windows to take place as each window is without it.  My contract states that windows will be "installed" not just hung.  Currently the effort is without proper installation and are in fact just hung.

  Along with that- visual renderings showed I would get 3 windows per side of the front door of the building.  At time of installation the installer refused to put these windows in as he said it would impact the lean to supports.  With that- 2 windows that were brought to install were not installed.  By this- I was sold an image of a building that I did not receive. The esthetic of the building lost some of its appeal from this issue.  I have been told there is nothing than can be done however I feel something should be compensated by this issue.  The fact that CCI still wants full invoice value when some of the effort was not completed is insane.  Invoice revision is warranted.

  The local branch has not been willing to hear any of the issues and since I don't want a shell of a building only- I have voided any support at all.  Who wants a metal building only..... people want to install lighting - AC- Heat - even water.  By your clause if its not left alone- nothing is kept under warranty.  People don't spend thousands of dollars to stare at a shell. You basically sell buildings without warranty with the way this clause is stated.

  To make this issue resolve I will need a revision to my final invoice for the two windows that were not installed and an adjustment for not receiving what I paid for in the esthetic of the building sold versus what I received.  

   

  
  

  Customer response

  07/24/2024

  Attached is the contract in which the building shows 12 windows in total to be in installed and a rendering of the front of the building referencing 6 windows.  Bound by the contract.

  Attached is my building today- with 4 windows installed. Breach in contract because the installer would not adhere to the contract the purchase was bound to.

  Business response

  07/25/2024

  As previously stated, CCI promotes and sells metal buildings for storage use only. The units can certainly be converted with the proper use of an engineer, architect and licensed contractor to bring it to occupied code. 

  Each customer is provided with the terms, conditions and warranties. The terms are very clear. ANY alteration voids ALL warranty. If any customer, contractor or otherwise were to suggest to CCI that they intended to use spray foam, we would very strongly suggest that not be done. The alterations to this unit are impactful to the structural integrity of the unit and all warranties are void. 

  The customer signed the contract acknowledging that alterations void warranty. 

  Business response

  07/25/2024

  The configuration was not provided by CCI, that was provided by the dealer who sold the unit who is independent of CCI. The configuration is not physically possible. The customers invoice has been revised to remove the charges for the 2 windows. This customers order is currently in collections as they withheld $2789.09. The window value is $480.38. The customer owes $2308.71. 

  Customer response

  08/09/2024

   I am rejecting this response because:  

  Thank you for this opportunity to respond.

   

  Unfortunately I am not willing to accept that CCI was unaware of the design of this building prior to erection on the premises.  Renderings were attached to the CCI contract that show the VOID in warranty clause that CCI is holding me to.  The PDF package has the CCI contract and renderings together- along with blue print for window install.  12 windows came with the building to be stood up.  Header bars are made at the plant- not on sight.  The CCI contract shows 12 windows were to be installed.  I was sold a building that would have 6 windows on the front.  4 were installed.  To me, you sold a dream that you were not willing to provide.   That is false pretense.  I would like a compensation for this.  Refund of just the widows/ install is not enough.  You provided drawings/ a contract/ and visual that something was going to provided that was not. 

   

  Final resolution of this issue would require a large credit to the final bill.  I will not accept the window credit only.

   

   

  Thank you again and have a super weekend!

   

  *************************

  
  
  
  

  Business response

  08/09/2024

  The renderings were not generated by CCI. They were generated by the dealer who sold the unit. CCI does not sale directly to the public, all sales go through a network of dealers. 

  CCI manufactures the parts, pieces, components. We are also not engaged in the install of the structure. CCI is like the Lowes Hardware of carport materials. The materials are purchased by the contractors for install. If the initial rendering was not a feasible install or the customer feels misled by the sales process, they would need to speak with the dealer regarding that. CCI is not involved in any of those conversations. 

  At this time, the customer has been sent for legal action review for their open balance. 

  Customer response

  08/09/2024

   I am rejecting this response because: CCI knew full good and well what these building should look like by the floor plan and renderings.  I have made contact with **** at Viking and CCI is given the renderings and drawings AND approve them before the sale.  Unfortunately CCI is aware of the installer as CCI schedules them and pays them under the CCI purchase contract. They ARE CCIs sub. Also, attached is an email of the generic plans from CCI in order to make sure our pad is correct for install.  CCI is way more then a Lowes hardware supplier.  Please understand that I know CCI is more involved then what is being stated. 

   

  
  

• Initial Complaint

  07/12/2024

  Complaint Type:

  Service or Repair Issues

  Status:

  Answered

  More info

  I recently purchased a carport from Carolina Carport, and unfortunately, my experience has been far from satisfactory. While the initial installation took place June 10, 2024, I realized that not everything I ordered was included. I've been trying to resolve this issue for over a month now, calling multiple times and sent an email, but all I ever hear is that they are aware of the problem and waiting to be back in my area to complete the installation properly.It's frustrating because I wasn't the one who made the mistake of not bringing all the necessary supplies initially, yet I'm the one facing the consequences. This lack of accountability and delay in resolving the issue reflects poorly on their customer service and commitment to customer satisfaction. I hope they can rectify this situation promptly so that I can finally enjoy the complete product I paid for.

  Business response

  07/12/2024

  I am in receipt of the customers concerns. 

  Unfortunately there appears to be a bit of miscommunication on this project. CCI is the manufacturer. According to the notes from the contractor that installed the unit, the customer was choosing to take the reduced balance and keep the unit as is. The customer paid the reduced balance. There was not a service order issued. 

  I have updated the state rep with the correct information. We have a contractor that will be in the area next week to take care of this. The customer will be receiving a call from scheduling shortly. 

  We very sincerely apologize as we were not given the correct information. 

  Sincerely,

  *************************

  CCI General Manager

  ***********************. 

  ************************************

   

  Customer response

  07/12/2024

   I am rejecting this response because:
  CCI is such a liar. When the guy was on site he called the office and put me on the phone and I was told then someone would reach out to me to schedule a date to come back out which I agreed to. 1 week later I still hadn't heard from CCI so I called them. I was told we have you down and when someone is in your area we will put you on the schedule. Which led to 1 month later and still no attempt from CCI to make rectify THEIR mistake with the original order. Not until I involve BBB that I finally get a call saying I'm being put on the schedule. I will update when they do come out to rectify THEOR mistake. The installer tried to get me to pay the full amount and I said I'm not paying for something I didn't get and will pay the rest once it is finished. I will know next time if I'm ever in this situation get it in writing because business will lie to cover their butt's. SO disappointed in CCI with the lies told. 

  Customer response

  07/18/2024

   I am rejecting this response because:
  Well CCI didn't show up when they said they would Wednesday 7/17. I waiting all day long and they were a no-call no-show. Whatever happen to customer service? A courtesy call would have been nice. But, no I didn't get a phone call and as of now they still haven't shown up this morning either. 
  
  

  Business response

  07/23/2024

  The contractor has advised that the service order is complete. They were running behind due to weather and heat. They attempted to contact the customer to let them know they would be behind but the call was sent to a voicemail that was full. 

*Some consumers may elect to not publish the details of their complaints, some complaints may not meet BBB's standards for publication, or BBB may display a portion of complaints when a high volume is received for a particular business. ↩